Search

GREAT RIDES & STAYS!
Fab Ads
Page 9 of 9 < 1 2 3 4 5 6 7 8 9
Topic Options
Rate This Topic
#145396 - 05/24/19 06:53 PM Re: New Old Rider From OK [Re: Vinduroman]
Vinduroman Offline
Junior Member
*****

Registered: 04/12/19
Posts: 63
Loc: OK
As of this morning my little XT225 is at the dealer for fixin'.

On to the next bike: My '73 CZ 175 Trail. (Needs a full-on restoration.)

V-man

Top
#145664 - 07/11/19 09:07 PM Re: New Old Rider From OK [Re: Vinduroman]
youngfred Offline
Junior Member

Registered: 08/19/18
Posts: 24
Loc: Somewheres, In Texas
...


Where you at?


youngfred
_________________________
2000 - XT225

Top
#145821 - 08/10/19 04:54 AM Re: New Old Rider From OK [Re: Vinduroman]
Vinduroman Offline
Junior Member
*****

Registered: 04/12/19
Posts: 63
Loc: OK
I'm BACK!

Reason for my absence: All this time the XT225 has been at the shop. In fact, I just brought it home yesterday, late afternoon... FINALLY!

It was a long and sordid story of sorting issues. Fortunately, I've known the owner of the shop for decades (having purchased several Yamaha's from his dad that owned the shop at the time), so he took it in, and worked on it when practical (used it as filler work, not assigned/dedicated work) because he figured tracing the issue would be lots of trial and error so was trying to hold down my costs. (i.e. In other words, he would work on when he could and not assign one of his commissioned mechanics, thus avoiding me being dinged with the $$$ hourly shop rate as one of his commissioned help experimented and invested a lot of time trying to find all the issues.)

He did good keeping me informed with calls, and amid him being gone for a total of three weeks (2 for vacation and a business type trip), he kept chipping away at it when he could.

Several things were found that were contributing to the issue, and a couple weeks ago they were oh-so-close. He called me again at that time to let me know they had the top end running clean and it would pull good to the top, but he wasn't satisfied with the way it felt off-idle and suggested I come ride it to see if I concurred.

I rode it around town for quite a while, and yes, the load-induced miss was gone and it would pull good to the top, but it was a bit hesitant off idle and at times felt like it wanted to die. I concurred with his estimation and left it with him. I told him no rush, work on it when he could, but get it as good as he could get it before I pick it up.

He then disassembled the carb (again) and started spec-ing the air/fuel idle circuit. When it was all said and done, a previous owner/whomever had wallowed out not only the main jet (replacing it with a new UNTOUCHED jet was what cleaned up the top end) as well as modified the pilot jet. Once he determined this, a new pilot jet went in, some tuning, and presto: Runs like a top. Idles nice and smooth, immediate response off idle... pulls great and runs clean to the top.

SO... there you have it!

Once the weather gets more agreeable (my region is in our 100+ summer weather right now) I will start riding it in the cool of the mornings for extended periods to insure that all is good before I start going on rides out in the mountains.

BUT... it's home... FINALLY!!!

All fer now.

V-man

Top
#145822 - 08/10/19 02:59 PM Re: New Old Rider From OK [Re: Vinduroman]
Az4x4 Online   content
Platinum Member
*****

Registered: 08/18/08
Posts: 4286
Loc: Heber/Overgaard, AZ

Good to know your bike's up and running again. Nice to have a dealer who'll chip away at the bike's issues on the side until he's got things sorted. Enjoy your XT now that it's running well, and keep the rubber side down!
_________________________
Lovin' life in Arizona's Mogollon Rim Mountain Country!!

Top
#145886 - 08/19/19 02:19 PM Re: New Old Rider From OK [Re: Vinduroman]
Vinduroman Offline
Junior Member
*****

Registered: 04/12/19
Posts: 63
Loc: OK
Just an update:

I've spent some time on my little XT225 over the weekend during the cooler portions of the day. Yesterday evening I rode it about 40 miles or so, up and down a mountain, some back road, a bit of highway, etc. Nary a burp nor a spit. Pulls good off idle and runs out nicely when asked to.

I do believe it's fixed. I will be picking up the new speedo cable w/housing this week and installing it eventually. Once the garage cools off (really hot weather right now), and it goes back onto the lift stand, I will install the cable, rehang the tank shrouds, flush/refill the forks and look it over. It will then be ready to ride up in the mountains beginning sometime in late September. (Or when the weather finally drops down into the 80s!)

Looks to be a keeper!

V-man

Top
#145887 - 08/19/19 02:28 PM Re: New Old Rider From OK [Re: Vinduroman]
Muniac Offline


Platinum Member
*****

Registered: 01/16/04
Posts: 5801
Loc: Montrose, CO
You might want to move further discussions to an appropriate forum. Thanks.
_________________________
Evolve & Simplify
Be There or Be Nowhere! A Few Adventures & Video

Top
#145889 - 08/20/19 12:01 AM Re: New Old Rider From OK [Re: youngfred]
Vinduroman Offline
Junior Member
*****

Registered: 04/12/19
Posts: 63
Loc: OK
Originally Posted By: youngfred
...


Where you at?


youngfred


Sorry, didn't see this at first. I'm in eastern OK.

Muniac:

Will do.

V-man

Top
#145895 - 08/21/19 02:04 PM Re: New Old Rider From OK [Re: Vinduroman]
Muniac Offline


Platinum Member
*****

Registered: 01/16/04
Posts: 5801
Loc: Montrose, CO
No problems. Just trying to keep information where it best fits and can be found later on. Thanks.
_________________________
Evolve & Simplify
Be There or Be Nowhere! A Few Adventures & Video

Top
Page 9 of 9 < 1 2 3 4 5 6 7 8 9

Web & Site Search
Google
 
Custom TO Customer
Specialty Resource
Fab Ads
Boardcaster Updates

Board Upgrade: Board upgrade to V7.5.8 has been completed on Tuesday Sept 2nd 2014. This should solve the missing posts problem. Enjoy the new software!

Who's Online
0 registered (), 55 Guests and 3 Spiders online.
Key: Admin, Global Mod, Mod
Shout Box

Top Posters
Reggie 11645
alexd 5915
Muniac 5801
Moto Psycho 4684
Az4x4 4286
peejman 3269
kris 2366
Paul49 1736
Doc250 1643
JerryH 1518
Forum Stats
5338 Members
38 Forums
15919 Topics
142652 Posts

Max Online: 149 @ 11/09/12 11:04 PM
Newest Members
8lives, bab029, CrozetVA, Jellyfishlicker, Woodytoo
5338 Registered Users
October
Su M Tu W Th F Sa
1 2 3 4 5
6 7 8 9 10 11 12
13 14 15 16 17 18 19
20 21 22 23 24 25 26
27 28 29 30 31